Product ID:ABLEFILM 566K
MSDS Date:02/26/1988
FSC:8040
NIIN:01-355-3816
MSDS Number: BSSPJ

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

20021 SUSANA ROAD
RANCHO DOMINGUEZ, CA 90221
US

Emergency Phone: 213-764-4600

Info Phone: 213-764-4600/800-424-9300(CHEMTREC)

Cage: 21109

ABLESTIK LABS SUB OF NATIONAL STARCH AND CHEMICAL

COMPTON, CA 90221 US

Telephone: 310-764-4600

Cage: 21109

ACRYLONITRILE (SARA III)

CAS: 107-13-1

RTECS: AT5250000

Fraction By Weight: <0.001%

OSHA PEL S,2PPM/C,10PPM

ACGIH TLV: S, 2 PPM; 9293

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:YES
Health Hazards Acute and Chronic:ACRYLONITRILE IS CONSIDERED TO BE
CARCINOGENIC. IRRITATION TO SKIN.
Explanation of Carcinogenicity:ACRYLONITRILE IS CONSIDERED TO BE
CARCINOGENIC BY OSHA, IARC,ACGIH & NTP
Effects of Overexposure:INHALED: NOT LIKELY TO PRODUCE ADVERSE EFFECTS
DUE TO ITS LOW VOLATILITY. SKIN: PROLONGED REPEATED CONTACT MAY
CAUSE IRRITATION TO SENSITIVE INDIVIDUALS. EYES: SHOULD NOT CAUSE
IRRITATION DUE TO ITS LOW VAPOR PRESSURE. INGESTION: INFORMATION
IS NOT AVAILABLE BUT, SLIGHT POTENTIAL FOR ORAL TOX
Medical Cond Aggravated by Exposure:SKIN CONDITIONS

First Aid:EYE: FLUSH W/H20 FOR 15 MIN. GET MD ATTEN. SKIN: WASH W/SOAP
& H20. IF IRRITATION PERSISTS GET MD ATTEN. INHAL: REMOVE TO FRESH
AIR IMMEDIATELY. INGESTION: SEEK MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:CC
Flash Point:>400F,204C
Lower Limits:NOT AVAILABE
Upper Limits:NOT AVAILAB
Extinguishing Media:CARBON DIOXIDE, FOAM, DRY CHEMICAL
Fire Fighting Procedures:WEAR SELF CONTAINED BREATHING APPARATUS &
PERSONEL PROTECTIVE EQUIPMENT.
Unusual Fire/Explosion Hazard:NONE KNOWN

Spill Release Procedures:SWEEP UP AND COLLECT IN AN APPROPRIATE
CONTAINER FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:USE ADEQUATE VENTILATION. LOCAL EXHAST
IS RECOMENDED WHEN APPROPRIATE TO CONTROL EXPOSURE. STORE FROZEN
AT ALL TIMES
Other Precautions:AVOID CONTACT WITH SKIN AND EYES AND CLOTHING, GOOD
HOUSEKEEPING IS REQUIRED. AVOID INHALATION OF VAPORS.

Respiratory Protection:USE NIOSH APPROVED ORGANIC VAPOR RESPIRATOR IF
NEEDED.
Ventilation:LOCAL EXHAUST IS RECOMMENDED, USE ADEQUATE VENTILATION
Protective Gloves:RUBBER
Eye Protection:SAFETY GOGGLES & SPLASH SHIELD
Other Protective Equipment:PROTECTIVE CLOTHING TO COVER EXPOSED AREAS
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING AND BEFORE
EATING, DRINKING OR SMOKING. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
VENT CURING OVEN OUTDOORS

Boiling Pt:B.P. Text:NOT AVAILA
Melt/Freeze Pt:M.P/F.P Text:NOT AVAILA
Decomp Temp:Decomp Text:NOT AVAILAB
Vapor Pres:NOT APPLIC
Vapor Density:NOT APPLIC
Spec Gravity:2.3
Evaporation Rate & Reference:NON-VOLATILE SOLID
Solubility in Water:INSOLUBLE
Appearance and Odor:WHITE FILM; ODORLESS
Percent Volatiles by Volume:<1%

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS AND STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:HEAT PRIOR TO CURE
Hazardous Decomposition Products:CARBON MONOXIDE, ALDEHYDES AND ACIDS.
POSSIBLE FORMATION OF CYANIDE COMPOUNDS UPON INCOMPLETE COMBUSTION
Conditions to Avoid Polymerization:EXCESSIVE HEAT. IF PRODUCT IS NOT
USED FOR THIN BOND LINE APPLICATION, VIOLENT CHEMICAL REACTION MAY
RESULT.

Waste Disposal Methods:DISPOSAL MUST BE IN ACCORDANCE WITH ALL
APPLICABLE LOCAL, STATE AND FEDERAL REGULATIONS. COORDINATE WITH
SUPPORTING INSTALLATION AND/OR MACOM ENVIRONMENTAL OFFICE PRIOR TO
DISPOSAL

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.